How to fix a burnt coil in a disposable vape

How To Fix A Burnt Coil In A Disposable Vape? - Learn The Tips & Tricks

Do you notice any bitter or harsh taste,  and a gurgling sound during a puff from your disposable vape?

These signs indicate that your disposable device’s coil is burnt. Then, the device's coil will probably be burnt. The question is how to fix a burnt coil in a disposable vape.

Burnt coils have a sharp, bad taste as the heating material inside them gets too hot or dry. 

This can happen for several reasons:

  • Using e-liquids that are too sweet and causing the wick to caramelize on the coil
  • Due to not priming the coil to absorb the e-liquid in between hits.
  • Chain vaping or overheating 

By the end of this blog, you’ll be mastering how to fix the burnt coil of your disposable vape. Also, we will cover how you can avoid this problem in the future!

Disposable Vape Burnt Coil Problems And Solutions (In 50 Seconds!)

Your disposable vape coil can get burnt due to: 

  • Chain vaping
  • Overheating
  • Not priming the coil before use
  • Vaping on a high-wattage setting

How to fix a burnt coil in a disposable vape? Follow these steps- 

  • Start with disassembling the vape device- remove all parts- the battery cover, battery, cartridge, and coil. 
  • If the coil is repairable, clean it. 
  • If the coil is hardly burnt, replace it with a new one. 
  • Resemble the parts of the vape device. 
  • Prime the coil. 
  • Test the coil by vaping away. 
  • If the burnt flavor exists, it's time to get a new disposable vape. 

6 Reasons Your Disposable Vape Might Have A Burnt Coil

It happens to everyone when their coils burn out faster than expected; nevertheless, there are many possible causes.

  • Preparing Your Coil For Use

While using a fresh coil, we often forget to prime it. You should fill your tank with e-liquid and let the coil soak for three to five minutes before vaping.

If given enough time, the dry cotton within the coil may absorb the necessary amount of e-liquid. Not doing this will result in vaping on dried cotton, which may irreparably damage your coil.

  • Over-vaping

If you inhale heavily too quickly without giving the coil a chance to reabsorb e-liquid, you risk burning it out. Additionally, the coil will overheat and begin to burn.

  • High Settings

While turning up the wattage output settings on your disposable vape, you're using an excessively high setting. Make sure you inspect your coil thoroughly since each one is unique.

We recommend starting with the recommended power limit and gradually increasing it if necessary. Be careful not to exceed the suggested dosage. That will cause your coil to get burned.

  • Sugary E-Juice

Does your e-liquid have a lot of sugar? If your coils are burning out rapidly, this might be the cause. In the world of electronic cigarettes, these substances are often known as coil-killers. 

  • Fraudulent Coils

It's shocking how many counterfeit vape items there are. Purchasing vaping accessories from unknown buyers can lead to falling into the traps of fake coils—consequently, the coil burns in just a few days of usage. The low price tag can entice you, but they are probably not authentic.

  • Chain Vaping 

When you chain vape, you take hit after hit without pausing, which might lead to coil overheating.

How To Fix A Burnt Coil In A Disposable Vape? (Step-by-step guide)

If the flavor in your disposable vape starts to taste burned, don't worry—there are ways to fix the faulty coil and enjoy vaping. The steps below show you how to fix a burnt coil in a disposable vape.

Dissembling the Device 

Step 1: Arrange The Necessary Tools

Ensure you have these tools arranged before you start- 

  • A small screwdriver
  • Cotton swabs or Q-tips
  • Forceps
  • Rubbing alcohol

Step 2: Remove The Vape Device’s Mouthpiece

You can easily pull out or twist off the tip of most disposable vapes. But for some devices, you might need to remove them or use a tool to get them open. Keep it somewhere clean and safe so that it doesn’t get dirty or lost. 

Step 3: Detach The Battery Cover By Unscrewing It

Depending on the year and model of the disposable vape device, removing the battery cover technique differs. Some devices need screws to unscrew, while others may be pried open using a tool to release their snap-in design.

Step 4: Take The Battery Out

After removing the battery cover, carefully remove the battery from its place. Be careful not to damage the battery or the device's insides.

Step 5: Take Out The Cartridge Or Tank

If the tank is removable, disconnect it and put it aside. For built-in tank devices, you might use a tool to open it up and take the tank off the battery. 

Step 6: Take Off The Coil

Carefully remove the burned coil from its appropriate spot with forceps or your fingers.

Get the Coil Clean

As you use your disposable vape several times, the coil starts to build up on it. As a result, it works less and starts to produce a burnt flavor. Cleaning the coil at regular intervals increases its performance.

You can clean your disposable device’s coil in the following methods- 

  • Use warm water to rinse

Clean your coil by washing it with warm water first. If there's dust or filth on its outside, this will help get rid of it. We don't recommend using hot water because it could damage or bend the coils.

  • Immerse in a Vinegar Soak

For tough buildup on the coils, use the vinegar solution. Take a jar, and mix an equal portion of white vinegar and water into it. Place the coil in the fluid and let it sit there for 30 minutes.

  • Use IPA or isopropyl alcohol

Soaking the coils in isopropyl alcohol (IPA) for 30 minutes is another good way to clean them.

  • First, wash it with warm water. After that, let it dry fully. Finally, put your disposable vape back together.
  • After soaking, you can also use a soft-bristled toothbrush to gently clean the coils and get rid of any extra moisture. Do not apply too much force, since this might damage the delicate coils.

Prime The Coil With E-Juice 

To avoid dry hits and ensure the coil wicks appropriately, you must soak it in e-liquid. 

  • Step 1: Fill the wicking holes with e-liquid. The design depends on the wicking holes, which are little apertures on either side or in the space between the coil's wrapping. Please do this by slowly dripping a few drops of e-liquid into each hole from the bottle until they are full but not spilling.
  • Step 2: Next, pour e-liquid over the top of the coil, the part that heats up. This will properly soak every part of the coil.

Put it aside for a little. After putting e-liquid in your tank, wait a few minutes so the coil has time to fully absorb the liquid.

Reassembling And Refilling The Device 

Fixing a burned coil in a disposable vape device finally comes down to reassembling and refilling the device. 

Follow the easy procedure below:

  • Inspect for any damage.
  • Put the tank back together and add e-liquid. If you removed the old coil, put it back on the tank.
  • Put the mouthpiece back on.
  •  If needed, replace the O-rings.
  • Give it time to sit.
  • Take a puff away

Remind yourself that if you notice a burned flavor again, it could be time to get a new disposable vape since you might irreparably break its battery or other parts.

Disposable Vape Safety 

Like any other kind of vaporizer, disposable vapes are susceptible to having their coils burn out. Ignoring or misusing the equipment is a common source of this off-flavor.

This part will discuss ways to keep your disposable vape coils from getting burned.

  • Get the Coil Primed Before You Use It

Only use your disposable vape once you have primed the coil correctly. Pour e-liquid upon the wick to avoid it burning while heated. Before you start vaping, soak the coil with a couple of drops of e-juice and wait for roughly ten minutes.

  • Do Not Chain Vape

Chain vaping may cause the coil to burn due to dry impacts. To sidestep this problem, pause briefly between puffs and let the coil rest for 30 seconds before continuing to hit.

  • Avoid Overfilling Your Device

Always fill the cartridge or tank no more than the line that says "maximum" while using the device. When the airflow holes are overfilled, the coil may be flooded with e-liquid, giving it a burned flavor.

  • Be Careful When Storing Your Device

Avoid burned coils by storing your disposable vape properly. Avoid using your device in very hot or sunny conditions. Doing so might lead the e-liquid to dissipate and spill into the atomizer, giving your vape a burned flavor.

  • Make Use Of Premium E-Liquid

Low-quality e-liquids often include contaminants and sweeteners, both of which have the potential to clog the wick. Because of this, the taste reminds you of burnt food. For the best results with your disposable vape, only use e-liquids from trusted brands.

New Disposable Vape Tastes Burnt (Reddit Solutions) 

Let's link up with the other vaping community and get to know what they're doing on this similar issue- a burnt coil of disposable vape: 

  • r/electronic_cigarette 
  • r/vaping 
  • r/dispsoablevapes 
  • r/DisposableVapeAUS
  • r/VapingUK 
  • r/chemistry
  • r/Elfbar_Community 
  • r/Advice 
  • r/aussievapers
  • r/CleaningTips 

Frequently Asked Questions

How To Fix Elf Bar Burnt Taste?

Next time, after you charge it, give your ELf Bar time to cool down before hitting up. It would be best to wait at least 30 seconds between hits. Also, try to charge the device as little as possible. 

We recommend waiting for the device to die first and then keeping it on a charge instead of charging while you think it's about to run out of battery. Don't unplug it until the battery is full. 

But, if you've used your Elf Bar for more than 2 or 3 weeks and are experiencing the shitty burnt taste, it's either discrepancies in manufacturing or user error. 

To know more read our blog on Elf Bar Tastes Burnt

Why Does My Rechargeable Vape Taste Burnt?

At the primary level, you can fix this issue by soaking the coal in the oil and waiting for one hour or two. However, if the burnt taste comes back after one puff, you can try the following:

  • Make sure you prime the coil before vaping. 
  • If the coil is slightly burnt, try to pull it out and leave it in warm water. 
  • Please put it back after drying it entirely for at least one day. 

But if you chain vape, the coil might get burnt so hard that the cotton on it burns, creating an awful taste. In this case, you would need to buy a new coil. 

How To Fix Elf Bar BC5000 Burnt Taste?

If your Elf Bar BC5000 is delivering a burnt taste, hold on to your vaping, and let the device cool down. Also, follow these steps:

  • Detach the device's mouthpiece and check the coil. If it appears gunky and dark, replace it. 
  • However, if the coil appears clean but still produces a burnt taste, rinse it with warm water to ensure there is no residue left. 
  • Properly dry it before resetting. 
  • Apply a few drops of e-juice on the replaced coil to prime it. It will ensure proper saturation and prevent drying hits.

Stay Safe While Smoking Disposable Vapes

Problems with disposable vape coils are prevalent but not unsolvable. 

After reading this guide, you should be able to vape more comfortably and save money by knowing the reasons behind the problems and how to fix them.

Back to blog